Tell us about the job
Takes about a minute. No obligation.
A contractor quoting furnace installation in Franklin County has to account for what the equipment will actually run against, not just the square footage of the house. 121 severe weather events were recorded in Franklin County, Illinois between 2015 and 2024. At that rate, severe weather is a standing feature of life here, not an occasional disruption, and a furnace that is sized and sealed to handle that load will hold up where a catalog install begins to lose ground at the joints and heat exchanger seams. The ductwork and the fit matter as much as the unit itself.
Ductwork laid down for equipment of that vintage was built to carry different airflow volumes than a modern furnace demands, and whether it does the job is what a contractor has to determine before the new unit is ever ordered. Half the homes in Franklin County, Illinois were built in 1963 or earlier (2020-2024 ACS 5-year). That age of construction means the electrical service, too, may have been configured around load expectations that a current furnace does not match. A contractor working in stock like this opens walls and measures before committing to a configuration, because the ductwork either passes or it shapes the entire scope of what gets quoted.
What Gets Installed With a New Furnace
The furnace itself sits in the basement, utility room, or closet and is the unit that produces heat for the house. Attached to it is the flue or exhaust pipe, which runs up through the house or out a side wall and carries combustion gases out. The blower motor inside the furnace cabinet pushes conditioned air into the supply side of the duct system.
The thermostat mounts on an interior wall and is the control point the homeowner sees every day. A new furnace also requires a gas line connection at the unit and a dedicated electrical connection for the controls and blower. The filter housing, which sits at the return-air inlet to the furnace, is part of this assembly and gets set up when the unit is placed.
The drawing shows a typical layout, and a licensed contractor determines exactly what applies to this house.
Get matched in Franklin CountyFranklin County, Illinois, by the numbers
121 severe weather events were recorded in Franklin County, Illinois between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Franklin County, Illinois were built in 1963 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFranklin County, Illinois holds 18,462 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 74.1% of the occupied homes in Franklin County, Illinois (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules for Franklin County, Illinois5 sourced standards and codes
What happens during HVAC installation in Franklin County
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Licensing and Legal Requirements in Franklin County, Illinois
Illinois leaves HVAC licensing to the municipality: state law lets the corporate authorities of each city or village examine, license and regulate heating, air conditioning and refrigeration contractors, and caps the licence fee they may charge at $50 — so who licenses you depends on the town you work in.
Severe Weather Events in Franklin County
Franklin County weather puts real demand on heating equipment, and how hard a furnace works over its life is a local fact, not a general one. That load history is part of what shapes the right installation decision for this area.
121 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.